Parking Garages and Concrete
Ohio Supermax Prison – Hubbard, OH
St. Elizabeth Materials Service Center and Intensive Care – Youngstown, OH
Phase 1 – A 44,000 square foot, two-story, below-grade structure houses prep and clean work rooms, sterilization areas, distribution stores, sterile stores, receiving and decontamination, cart holding and staging, mechanical and electrical rooms, and related areas.
Phase II – A 44,000 square foot, two-story structure constructed atop Phase 1 houses twelve surgical intensive care units, ten coronary surgical care units and related offices.
Phase 1 – Reinforced, cast-in-place concrete walls and floors; EPDM roof system
Phase II – Reinforced, cast-in-place concrete walls and floors; structural studs with masonry veneer; EPDM roof systemMike Coates Construction performed General Trades for Phase 1- (Perkins & Will Architects/Engineers, Washington, D.C.) and all Trades for Phase II (Hanahan/Strollo & Associates, Inc., Youngstown, Ohio)
Parking Deck & Pedestrian Bridge Connector – St. Elizabeth Hospital Medical Center
Parking Deck – The 179,847 square foot, three-story structure has two open parking levels and a ground level which houses offices and maintenance operations.
The Bridge Connector – A 500 linear foot, one-story, elevated structure connects the main hospital, parking deck, ambulatory surgical center, and dental clinic.
Parking Deck – Caissons; cast-in-place, post-tensioned concrete; and face brick veneer at exterior elevations.
Bridge Connector – Caissons, cast-in-place concrete floor, structural steel, structural studs with exterior insulation and finish system, EPDM roof system. Mike Coates Construction Co., Inc. performed all trades on project.
St. Elizabeth South Addition – Youngstown, OH
United States Postal Service Distribution Center – Akron, OH
This design-build project included the construction of an 80,000 square foot, two-story addition to the existing processing and distribution center. The addition includes a 45,000 square foot work area over an on-grade 80 car parking garage.
The walls and foundations of the on-grade parking garage and the floor of the second level work area are constructed of formed concrete. The floor of the on-grade parking garage is constructed of cast-in-place concrete. The walls of the second level work area are masonry and the roof over this same area consists of a membrane roofing system on steel joints and steel deck. The Project utilized the design-build method of project delivery. Mike Coates Construction Co., Inc. was responsible for all design and construction associated with the Project.